Product ID:30 CUT ORANGE BULLS EYE SHELLAC SOLUTION
MSDS Date:01/08/1987
FSC:8010
NIIN:00-165-4765
MSDS Number: BKZWW

ZINSSER WILLIAM AND CO

39 BELMONT DR
SOMERSET, NJ 08873-1218
US

Emergency Phone: 201-469-8100

Info Phone: 201-469-8100

Cage: 3M602

ZINSSER WILLIAM AND CO

SOMERSET, NJ 08873-1218 US

Cage: 3M602

ETHYL ALCOHOL (ETHANOL)

CAS: 64-17-5

RTECS: KQ6300000

Fraction By Weight: 50-60%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM; 9192

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: <10%

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

METHYL ALCOHOL (METHANOL) (SARA III)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: <4%

OSHA PEL S,200PPM/250STEL

ACGIH TLV: S,200PPM/250STEL; 93

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:HIGH CONCENTRATION OF VAPOR MAY CAUSE
HEADACHE, DROWSINESS, NAUSEA AND DIZZINESS AS WELL AS IRRITATION OF
THE EYES AND RESPIRATORY TRACT. PROLONGED CONTACT WITH SKIN MAY
CAUSE IRRITATION. INGESTION CA N CAUSE NAUSEA AND VOMITING.

First Aid:EYES: IRRIGATE WITH COPIOUS AMOUNT OF CLEAN WATER FOR 15
MINUTES. OBTAIN MEDICAL ATTENTION. SKIN: WASH SKIN WITH COOL WATER.
INHALATION: MOVE SUBJECT TO FRESH AIR; MAINTAIN BREATHING; OBTAIN
MEDICAL A TTENTION IMMEDIATELY. INGESTION: CALL PHYSICIAN OR POISON
CONTROL CENTER IMMEDIATELY.

Flash Point:54.0F,12.2C
Lower Limits:3.3
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG, SAND.
Fire Fighting Procedures:NONE

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. PROVIDE
ADEQUATE VENTILATION OR USE RESPIRATORY PROTECTION IN CONFINED
AREA. CLEAN AREA WITH ABSORBENT MATERIAL, SAND AND RAGS.

Handling and Storage Precautions:STORE IN A COOL PLACE AWAY FROM HIGH
HEAT, OPEN FLAMES, SPARKS AND OXIDIZING AGENTS. USE ONLY WITH
ADEQUATE VENTILATION.
Other Precautions:AVOID PROLONGED BREATHING OF VAPOR OR SPRAY MIST AND
PROLONGED CONTACT WITH SKIN. DO NOT TAKE INTERNALLY. KEEP OUT OF
DIRECT SUNLIGHT. KEEP CONTAINER CLOSED. DRUM SHOULD BE GROUNDED AND
BONDED WHEN PO URING.

Respiratory Protection:NONE REQUIRED IN WELL VENTILATED AREAS. IN
CONFINED AREAS WHERE HIGH VAPOR CONCENTRATIONS ARE EXPECTED, USE
NIOSH/MSHA APPROVED RESPIRATORY PROTECTION IN ACCORDANCE WITH 29CFR
1910.134.
Ventilation:USE EXPLOSION-PROOF EXHAUST SYSTEM SUITABLE TO KEEP VAPOR
CONC BELOW TLV/PEL. VENT EXHAUST VAPORS TO NONEXPLOSIVE AREA.
Protective Gloves:FOR PROLONGED CONTACT.
Eye Protection:SAFETY GLASSES.
Other Protective Equipment:CLOTHING ADEQUATE TO PROTECT SKIN.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health

HCC:F2
Boiling Pt:B.P. Text:173F,78C
Vapor Density:> AIR
Spec Gravity:7.52 LB/GL
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:BEIGE OR ORANGE LIQUID WITH ALCOHOL ODOR.
Percent Volatiles by Volume:77

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE ON INCOMPLETE
COMBUSTION.

Waste Disposal Methods:DRIED SHELLAC CAN BE DISPOSED OF IN TRASH.
DISPOSE OF SOLUTION IN ACCORDANCE WITH LOCAL, STATE OR FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.